Product ID:25-435, OMC OUTBOARD LUBRICANT
MSDS Date:06/18/1990
FSC:9150
NIIN:00N019785
MSDS Number: BNNNP

CITGO PETROLEUM CORP

TULSA, OK 74102
US

Emergency Phone: 318-491-6215

Info Phone: 918-495-5933

Cage: 7X110

CITGO PETROLEUM CORP

3758 TULSA, OK 74102 US

Telephone: 918-495-5933

Cage: 7X110

REFINED PETROLEUM OILS CONTAINING INGREDIENTS 2 & 3.

RTECS: 9999999ZZ

Fraction By Weight: 65-80%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3;10 STEL

MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINED HEAVY

CAS: 64741-88-4

RTECS: PY8040500

SOLVENT REFINED RESIDUM

CAS: 64742-01-4

STODDARD SOLVENT; (MINERAL SPIRITS)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: <25%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

ASHLESS DISPERSANT AND ANTI-OXIDANT

Fraction By Weight: <12%

RUST INHIBITOR

Fraction By Weight: <1%

(ORAL,RAT) 12.6 G/KG

Fraction By Weight: <0.1%

DEBRIDEMENT. IF NOT FAMILIAR WITH TECHNIQUE, SEEK

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SLIGHTLY TO MODERATELY TOXIC. LETHAL
DOSE FOR 150 LB HUMAN ADULT MAY BE 10 TO 250 ML. ACUTE: INHAL:LOW
RISK OF INHAL. IN ENCLOSED SPACES/WHEN HOT, VAPS MAY REACH CONC
SUFFICIENT TO CAUSE DROWS, DIZZ, HDCH, NAUS/LUNG IRRIT. MISTS
ABOVE TLV MAY CAUSE CHEM PNEUM. SKIN:MILD IRRIT. EYE:MILDLY IRRIT.
INGEST:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: TOX IS RELATIVELY LOW, HOWEVER, OF A
SAYBOLT VISCOSITY OF ABOUT 185(100F), THERE EXISTS STILL SOME RISK
OF ASPIR INTO LUNGS. ON INGEST OF LRG QTYS, SLIGHT GI DISCOMFORT,
DIARR & HDCH MAY OCC UR. SM DOSES MAY PRODUCE IRRIT &
DIARR.CHRONIC: PRLNGD AND/OR FREQ SKIN CONT MAY CAUSE DRYING,
CRACKING (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE

First Aid:INHAL:REMOVE TO FRESH AIR. RESP SUPPORT, IF NECESSARY. CALL
MD. SKIN:WASH WITH SOAP & WATER. DO NOT WEAR HEAVILY CONTAM CLTHG
BEFORE LAUNDERING. EYES:FLUSH W/LRG VOLUMES OF WATER FOR AT LEAST
15 MIN. CALL MD IF ANY COMPLICATIONS ARISE. INGEST:DO NOT INDUCE
VOMITING. CALL MD. NOTE TO MD:FOLLOWING INGEST, AT A SAYBOLT
VISCOSITY OF ABOVE 185 SUS, (100F), THERE EXISTS STILL SOME RISK OF
(SUPP DATA)

Flash Point Method:COC
Flash Point:169F,76C
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING.

Spill Release Procedures:REMOVE SOURCES OF HEAT/IGNIT, PROVIDE ADEQ
VENT, CONTAIN LEAK. SM SPILLS:ABSORB W/SUITABLE MATL SUCH AS RAGS,
STRAW/SAND. LRG SPILLS:CONTAIN SPILL IN EARTHEN DIKES FOR LATER
RECOVERY. REPORT SPILLS AS REQUIRED TO APPROPRIATE AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE BELOW 150F. DO NOT APPLY HIGH
HEAT OR FLAME TO CONTAINER. KEEP SEPARATE FROM STRONG OXIDIZING
AGENTS. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:EMPTY CNTNRS MAY CONTAIN PRODUCT RESIDUE WHICH COULD
INCLUDE FLAMMABLE OR EXPLOSIVE VAPORS. COMBUSTIBLE LIQUID. DO NOT
INHALE VAPORS NOR PERMIT DIRECT SKIN CONTACT.

Respiratory Protection:NORMALLY NONE REQUIRED. IF HIGH VAPOR OR MIST
CONCENTRATIONS EXPECTED, USE NIOSH/MSHA APPROVED RESPIRATOR FOR
ORGANIC VAPORS AND MIST.
Ventilation:USE IN WELL VENT AREA. IN CONFINED SPACE, MECH VENT MAY BE
REQ TO KEEP LEVELS OF CERTAIN COMPONENTS Protective Gloves:OIL IMPERVIOUS GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:WEAR BODY-COVERING WORK CLOTHES TO AVOID
PROLONGED OR REPEATED EXPOSURE. LAUNDER SOILED WORK CLOTHES BEFORE
REUSE.
Work Hygienic Practices:WASH EXPOSED SKIN THOROUGHLY WITH SOAP AND
WATER. REMOVE SOILED CLOTHING.
Supplemental Safety and Health
EFTS OF OVEREXP:(DERMAT)/FOLLICULITIS. RPTD, EXCESSIVE EXPOSURE TO
MISTS/FUMES MAY INDUCE PULM IRRIT/CHRONIC BRONCH. FIRST AID
PROC:ASPIR INTO LUNGS. REMOVAL BY CUFFED TUBE LAVAGE MAY BE
CONSIDERED. A SPIR MATL MAY CAUSE CHEM PNEUM/LIPOID PNEUM.
SUBCUTANEOUS/INTRAMUSCULAR INJECTION REQ PROMPT SURGICAL(ING 8)

HCC:V4
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<20 @ 25C
Vapor Density:>1
Spec Gravity:0.86 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLUE/GREEN LIQUID, SLIGHT ODOR OF PETROLEUM
DISTILLATE.
Percent Volatiles by Volume:15-25

Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:THERMAL: CO*2, (CO UNDER INCOMPLETE
COMBUSTION).

Waste Disposal Methods:IT IS THE RESPONSIBILITY OF THE USER TO
DETERMINE IF THE MATERIAL IS A HAZ WASTE AT THE TIME OF DISP. CHECK
BEFORE DISPOSING TO BE SURE YOU ARE IN COMPLIANCE WITH ALL
APPLICABLE FEDERAL, STATE & LOCAL LAWS & REGS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.